Home

Ford Mondeo Turbo Actuator Electronic 2.0 And 2.2 TDCI 6nw-008-412 712120 G-221 , G-149 , G-221 #

ACTUATOR DEPOSIT £100

RRP: £128.00
Our Price: £80.00
Ford Mondeo Turbo Actuator For Sale With Lifetime Guarantee
Description

MONDEO TURBO ACTUATOR Ford Mondeo MK3 MK4 MK5 2.0 & 2.2 TDCI and TDDI

Reconditioned Turbo Actuator From Stock

EXCHANGE FORD MONDEO TURBO ACTUATOR

FROM STOCK USING UPGRADED MOTOR AND WORM GEAR

FOR LONGER LIFE



 

WE NOW OFFER A LIFE TIME GUARANTEE WITH UNLIMITED MILEAGE



 

Ford Mondeo Turbo Actuator Repair includes the

worm gear, motor and electronics calibrated

So Ready To Fit , Plug And PLAY

No Coding Or Programming Needed




phone number  07977990613



 

ACTUATOR DEPOSIT

WE NEED £100 DEPOSIT BEFORE POSITING ACTUATOR

As This Is An Exchange Part, So We Need Your Old Used Faulty Actuator Back

Just Add To Cart And buy now and pay, £100 deposit will be added To Bill

£100 deposit will be refund when you send your old actuator to us


 

if we get payment and before 3.00pm

then we can normally post it out same day

 

phone number  07977990613


 

GARRETT MONDEO TURBO PART NUMBER 728680 & 758226

4S7Q6K682EN, 4S7Q6K682EL, 4S7Q6K682EJ, 4S7Q6K682EF, 4S7Q6K682EE, 1578770, 1415651, 6Q7S6K682AD


 

HELLA Ford Mondeo Turbo Actuator Part Numbers

712120 6NW 008 412

G-221 & G-149 & G-139




 

THE PART NUMBER CAN BE FOUND

ON THE ALUMINUM SIDE OF THE ACTUATOR

DEPENDING ON THE CAR, YOU MAY HAVE TO REMOVE

THE ACTUATOR TO GET THE PART NUMNBER




 

OR SEND US YOUR CAR REG NUMBER

AND WE WILL CHECK IF THIS IS THE RIGHT

ACTUATOR FOR YOUR CAR



 

phone number  07977990613



 

FORD MONDEO ELECTRONIC TURBO ACTUATOR PROBLEMS CAN BE ANY OR ALL OF THE FOLLOWING

 

THE FORD MONDEO TURBO ACTUATOR HAS BEEN KNOWN FOR CUTTING OUT AND LOSING POWER WHEN HOT AND COLD, WITH THE ENGINE MANAGEMENT / GLOW PLUG LIGHT OR COIL LIGHT COMING ON THE DASH BOARD, AT THIS POINT THE CAR WILL GO INTO LIMP MODE / Limp Home Mode.

 

IF YOU HAVE BEEN TO A GARAGE OR MECHANIC TO CHECK THE PROBLEM, THEN THEY HAVE PROBABLY HAD YOUR Ford Mondeo ON A DIAGNOSTIC SYSTEM THE CAR WILL ALSO HAVE FAULT CODES STORED FOR THE TURBO ACTUATOR

 

P132A OR P132B OR BOTH

Fault Code: P132A – Turbo Actuator Vane Fault Code

P132B – Turbo Boost Control A Performance

Intermittent Loss Of Power Under Acceleration

Actuator Arm Not Moving At All Or When Hot

No Boost

Loss Of Power

THE CAR WILL ALSO HAVE FAULT CODES STORED FOR THE TURBO ACTUATOR

P132A OR P132B OR BOTH



 

THIS WILL START OUT BY HAPPENING SOMETIMES AND NOT AT OTHER TIMES

BUT EVENTUALLY YOU CAR WILL BE STUCK IN LIMP MODE, UNTIL THE TURBO ACTUATOR HAS BEEN REPAIRED AND THE VANES IN THE TURBO CLEANED.

BEFORE FITTING OUR ACTUATOR


 

PLEASE CHECK THE ACTUATOR ROD WHICH GOES INTO THE TURBO

AND MAKE SURE THE TURBO VANES ARE NOT STICKING TO STUCK

IF THE VANES ARE STUCK THEN YOU WILL NEED TO CLEAN OR REPLACE

THE TURBO VANES BEFORE FITTING YOUR REPAIRED TURBO ACTUATOR

OR THE ACTUATOR WILL BURN OUT AGAIN




 

HOW TO CHECK IF THE TURBO VANES

With the engine warm or hot take the cir-clip off the arm on the actuator side so the actuator is now disconnected from the actuator rod then push and pull the actuator rod arm very gently, to see if it moves freely or sticks at any point. You will probably find it sticks and does not move the full range or freely, normally the vanes will stick or go tight at either end, especially when hot.




 

TURBO CLEANER

WE ONLY RECOMMEND USING FORTE TURBO CLEANER

PUT 2 BOTTLES IN A FULL TANK OF FUEL

DRIVE SLOWLY FOR 200 MILES - ANY TIME THAT SUITS YOU

THEN DRIVE HARD FOR 20 MILES - IN ONE OR TWO RUNS

THIS SHOULD DISSOLVE ALL THE CARBON AND THE SOOT BUILD UP

IN THE TURBO VANES



 

NOTE THAT 80% OF ELECTRONIC TURBO ACTUATOR FAILURES

ARE DUE TO THE VANES BEEN BLOCK UP BY CARBON IN THE TURBO

CAUSING THE MOTOR AND THE WORM GEAR TO WEAR OUT

AND EVENTUALLY FAIL.





 

Turbo Vanes
Suite 115 
51 Pinfold Street
Birmingham
West Midlands
UK
B2 4AY


07977990613



 

MANY OTHER RECONDITIONED TURBO ACTUATORS AVAILABLE

MPN: 6NW 008 412
EAN: 712120
UPC: EAG-221-F
Facebook
Google Plus

Customer Reviews
Write an online review and share your thoughts with other shoppers!